| Calculation to determine use of " StrongBack Products " |
|
| for repair or rehabilitation of pipelines : |
|
|
| Enter information in yellow boxes
- Results
in red |
|
| Enter the REMAINING wall
thickness, inches |
|
0.089 |
|
| Enter the pipe Specified Minimum Yield
Strength (SMYS), psi |
46,000 |
|
| Enter the pipe OD, inches |
|
48 |
|
| Remaining capacity, psi ( line pressure for
correct repair) |
123 |
|
|
| Calculation for " StrongBack " layers: |
|
|
| Enter system design pressure,PSI(or max work pressure x 1.5) |
2427 |
|
| Barlows formula and StrongBack's ultimate tensile strength |
2304 |
|
| will indicate
the number of layers required for permanent repair / |
107.17 |
|
| rehabilitation:( 8 layer min.up to
10"od/10 layer min.over 10"od ) |
108 |
|
|
|
|
|
|
| Number of StrongBack rolls required. |
|
| Enter roll width, 2 - 3 - 4 - 6 or 10 inches |
10 |
|
| Enter length of repair in inches ( feet x 12 for
inches ) |
10 |
|
| Enter length of roll in inches ( feet x 12 for inches ) |
1080 |
|
| Enter exactly the following formula: =sum(p1:pX) ,substitute the |
|
| the value of "G14" ( number of layers ) for X and hit "enter" |
0 |
|
|
| StrongBack rolls required: (round up to next whole roll or to |
14.76 |
|
| minimise
possible waste analyze the decimal portion of this number |
|
| to establish the use of shorter roll equivalent to the decimal
fraction ) |
|
|
|
|
|
| GS-561G required: ( portion of or number
of 2 gallon kits ) |
0.21 |
(of two gallons) |
|
| equivalent to pint kits of GS561P |
1.7 |
|
|
64 |
|
|
123 |
|
| Installation TIME per meter of pipe is |
|
236.0 |
minutes, |
|
236 |
|
| that is equivalent to |
71.9 |
minutes per foot. |
|
| ( These times are approximate and assume a crew of three
qualified technicians for pipes 16" and |
|
| larger, and a crew of two for pipes smaller than 16".) |
|
| NOTE:
These calculations are provided by The StrongBack Corporation |
|
| to estimate the amount of product needed for a particular repair
and are |
|
| subject to verification by your Engineering Department. The StrongBack |
|
|
|
| Corporation
assumes no responsibility what so ever for the misuse or |
|
| modification to this electronic page. |
|
|
|
|
|
|
|
|
|
|
|
|
|
